Functional evaluation of Bacillus licheniformis PF9 for its potential in controlling enterotoxigenic Escherichia coli in weaned piglets.

During the bacterial selection, isolate PF9 demonstrated tolerance to low pH and high bile salt and an ability to extend the lifespan of Caenorhabditis elegans infected with enterotoxigenic Escherichia coli (ETEC; P < 0.05). Thirty-two weaned piglets susceptible to ETEC F4 were randomly allocated to four treatments as follows: 1) non-challenged negative control group (NNC; basal diet and piglets gavaged with phosphate-buffered saline), 2) negative control group (NC; basal diet and piglets challenged with ETEC F4, 3 × 107 CFU per pig), 3) positive control (PC; basal diet + 80 mg·kg-1 of avilamycin and piglets challenged with ETEC F4), and 4) probiotic candidate (PF9; control basal diet + 2.5 × 109 CFU·kg-1 diet of B. licheniformis PF9 and piglets challenged with ETEC F4). The infection of ETEC F4 decreased average daily gain and gain:feed in the NC group when compared to the NNC group (P < 0.05). The inoculation of ETEC F4 induced severe diarrhea at 3 h postinoculum (hpi), 36, 40 hpi in the NC group when compared to the NNC group (P < 0.05). The supplementation of B. licheniformis PF9 significantly relieved diarrhea severity at 3 hpi when compared to the NC group (P < 0.05). The inoculation of ETEC F4 reduced duodenal, jejunal, and ileal villus height (VH) in the NC group when compared to the NNC group. A significant (P < 0.05) decrease was detected in the duodenal VH in the PC and NNC groups. Moreover, the NNC group had a reduced relative mRNA level of Na+-glucose cotransporter 1 (SGLT1) when compared to the NC group (P < 0.05). Compared to the NC and NNC groups, the supplementation of B. licheniformis PF9 increased the relative mRNA levels of aminopeptidase N, occludin, zonula occludens-1, and SGLT1 (P < 0.05). The supplementation of B. licheniformis PF9 also significantly increased the relative mRNA level of excitatory amino acid transporter 1 when compared to the NC group (P < 0.05). Piglets supplemented with B. licheniformis PF9 showed lower relative abundance of Bacteroidetes in the colon than piglets from the NNC group (P < 0.05). The NNC group had a higher relative abundance of Firmicutes in the ileum than all the challenged piglets (P < 0.05); however, a lower relative abundance of Proteobacteria in the ileum and colon was observed in the NC group (P < 0.05). This study provides evidence that B. licheniformis PF9 has the potential to improve the gut health of piglets under challenging conditions.

High-level production of chitinase by multi-strategy combination optimization in Bacillus licheniformis.

In view of the extensive potential applications of chitinase (ChiA) in various fields such as agriculture, environmental protection, medicine, and biotechnology, the development of a high-yielding strain capable of producing chitinase with enhanced activity holds significant importance. The objective of this study was to utilize the extracellular chitinase from Bacillus thuringiensis as the target, and Bacillus licheniformis as the expression host to achieve heterologous expression of ChiA with enhanced activity. Initially, through structural analysis and molecular dynamics simulation, we identified key amino acids to improve the enzymatic performance of chitinase, and the specific activity of chitinase mutant D116N/E118N was 48% higher than that of the natural enzyme, with concomitant enhancements in thermostability and pH stability. Subsequently, the expression elements of ChiA(D116N/E118N) were screened and modified in Bacillus licheniformis, resulting in extracellular ChiA activity reached 89.31 U/mL. Further efforts involved the successful knockout of extracellular protease genes aprE, bprA and epr, along with the gene clusters involved in the synthesis of by-products such as bacitracin and lichenin from Bacillus licheniformis. This led to the development of a recombinant strain, DW2△abelA, which exhibited a remarkable improvement in chitinase activity, reaching 145.56 U/mL. To further improve chitinase activity, a chitinase expression frame was integrated into the genome of DW2△abelA, resulting in a significant increas to 180.26 U/mL. Optimization of fermentation conditions and medium components further boosted shake flask enzyme activity shake flask enzyme activity, achieving 200.28 U/mL, while scale-up fermentation experiments yielded an impressive enzyme activity of 338.79 U/mL. Through host genetic modification, expression optimization and fermentation optimization, a high-yielding ChiA strain was successfully constructed, which will provide a solid foundation for the extracellular production of ChiA.

Safety evaluation of the food enzyme glutaminase from the genetically modified Bacillus licheniformis strain NZYM-JQ.

The food enzyme glutaminase (l-glutamine amidohydrolase EC 3.5.1.2) is produced with the genetically modified Bacillus licheniformis strain NZYM-JQ by Novozymes A/S. The genetic modifications do not give rise to safety concerns. The production strain met the requirements for the qualified presumption of safety (QPS). The food enzyme is free from viable cells of the production organism and its DNA. The enzyme under assessment is intended to be used in six food manufacturing processes. Dietary exposure was estimated to be up to 0.148 mg TOS/kg body weight per day in European populations. Given the QPS status of the production strain and the absence of concern resulting from the food enzyme manufacturing process, toxicological studies were not considered necessary. A search was made for the similarity of the amino acid sequence to those of known allergens and one match with a pollen allergen was found. The Panel considered that the risk of allergic reactions by dietary exposure cannot be excluded, particularly for individuals sensitised to birch and oak pollen. The Panel concluded that the food enzyme does not give rise to safety concerns under the intended conditions of use.

Interspecies interactions in dairy biofilms drive community structure and response against cleaning and disinfection.

Interspecies interactions within a biofilm community influence population dynamics and community structure, which in turn may affect the bacterial stress response to antimicrobials. This study was conducted to assess the impact of interactions between Kocuria salsicia and a three-species biofilm community (comprising Stenotrophomonas rhizophila, Bacillus licheniformis, and Microbacterium lacticum) on biofilm mass, the abundance of individual species, and their survival under a laboratory-scale cleaning and disinfection (C&D) regime. The presence of K. salsicia enhanced the cell numbers of all three species in pairwise interactions. The outcomes derived from summing up pairwise interactions did not accurately predict the bacterial population dynamics within communities of more than two species. In four-species biofilms, we observed the dominance of S. rhizophila and B. licheniformis, alongside a concurrent reduction in the cell counts of K. salsicia and M. lacticum. This pattern suggests that the underlying interactions are not purely non-transitive; instead, a more complex interplay results in the dominance of specific species. We observed that bacterial spatial organization and matrix production in different mixed-species combinations affected survival in response to C&D. Confocal microscopy analysis of spatial organization showed that S. rhizophila localized on the biofilm formed by B. licheniformis and M. lacticum, and S. rhizophila was more susceptible to C&D. Matrix production in B. licheniformis, evidenced by alterations in biofilm mass and by scanning electron microscopy, demonstrated its protective role against C&D, not only for this species itself, but also for neighbouring species. Our findings emphasise that various social interactions within a biofilm community not only affect bacterial population dynamics but also influence the biofilm community's response to C&D stress.

Safety evaluation of the food enzyme subtilisin from the genetically modified Bacillus licheniformis strain NZYM-CB.

The food enzyme subtilisin (EC 3.4.21.62) is produced with the genetically modified Bacillus licheniformis strain NZYM-CB by Novozymes A/S. The genetic modifications do not give rise to safety concerns. The food enzyme is considered free from viable cells of the production organism and its DNA. It is intended to be used in six food manufacturing processes. The dietary exposure to the food enzyme-TOS was estimated to be up to 0.722 mg TOS/kg body weight (bw) per day in European populations. The production strain of the food enzyme fulfils the requirements for the qualified presumption of safety approach to safety assessment. As no other concerns arising from the manufacturing process were identified, the Panel considered that toxicological tests were not required for the assessment of this food enzyme. A search for the similarity of the amino acid sequence of the food enzyme to known allergens was made and 20 matches were found, including two food allergens (melon and pomegranate). The Panel considered that the risk of allergic reactions by dietary exposure cannot be excluded, particularly in individuals sensitised to melon and pomegranate, but would not exceed the risk from consumption of melon or pomegranate. Based on the data provided, the Panel concluded that this food enzyme does not give rise to safety concerns under the intended conditions of use.

Genome mining of Bacillus licheniformis MCC2514 for the identification of lasso peptide biosynthetic gene cluster and its characterization.

The probiotic strain Bacillus licheniformis MCC2514 has been shown to produce a strong antibacterial peptide and the whole genome sequence of this strain is also reported in our previous study. The present study is focused on the genome level investigation of this peptide antibiotic and its characterization. Genome mining of the culture revealed the presence of three putative bacteriocin clusters, viz. lichenicidin, sonorensin and lasso peptide. Hence, the mode of action of the peptide was investigated by reporter assay, scanning electron microscopy, and Fourier Transform Infrared spectroscopy. Additionally, the peptide treated groups of Kocuria rhizophila showed a reduction in the fold expression for transcription-related genes. The gene expression studies, quantitative ß-galactosidase induction assay using the RNA stress reporter strain, yvgS along with the homology studies concluded that lasso peptide is responsible for the antibacterial activity of the peptide which acts as an inhibitor of RNA biosynthesis. Gene expression analysis showed a considerable increase in fold expression of lasso peptide genes at various fermentation hours. Also, the peptide was isolated, and its time-kill kinetics and minimum inhibitory concentration against the indicator pathogen K. rhizophila were examined. The peptide was also purified and the molecular weight was determined to be ~ 2 kDa. Our study suggests that this bacteriocin can function as an effective antibacterial agent in food products as well as in therapeutics as it contains lasso peptide, which inhibits the RNA biosynthesis.

Regulator DegU can remarkably influence alkaline protease AprE biosynthesis in Bacillus licheniformis 2709.

Alkaline protease AprE, produced by Bacillus licheniformis 2709 is an important edible hydrolase, which has potential applications in nutrient acquisition and medicine. The expression of AprE is finely regulated by a complex transcriptional regulation system. However, there is little study on transcriptional regulation mechanism of AprE biosynthesis in Bacillus licheniformis, which limits system engineering and further enhancement of AprE. Here, the severely depressed expression of aprE in degU and degS deletion mutants illustrated that the regulator DegU and its phosphorylation played a crucial part in AprE biosynthesis. Further electrophoretic mobility shift assay (EMSA) in vitro indicated that phosphorylated DegU can directly bind to the regulatory region though the DNase I foot-printing experiments failed to observe protected region. The plasmid-mediated overexpression of degU32 (Hy) obviously improved the yield of AprE by 41.6 % compared with the control strain, which demonstrated the importance of phosphorylation state of DegU on the transcription of aprE in vivo. In this study, the putative binding sequence of aprE (5'-TAAAT……AAAAT…….AACAT…TAAAA-3') located upstream -91 to -87 bp, -101 to -97 bp, -195 to -191 bp, -215 to -211 bp of the transcription start site (TSS) in B. licheniformis was computationally identified based on the DNA-binding sites of DegU in Bacillus subtilis. Overall, we systematically investigated the influence of the interplay between phosphorylated DegU and its cognate DNA sequence on expression of aprE, which not only contributes to the further AprE high-production in a genetically modified host in the future, but also significantly increases our understanding of the aprE transcription mechanism.

Effects of dietary digestible amino acids and a novel exogenous sfericase protease on growth performance of broilers.

Two experiments (Exp.) were conducted to evaluate the effects of a novel exogenous sfericase protease on growth performance and ileal digestibility of broiler chickens until day 35 of age. In Exp. 1, 1350 one-day-old male chicks (Cobb 500) were allocated in 54 floor pens and fed one of the three dietary treatments, with 18 replicates of 25 birds each in a completely randomized design. Diets consisted of positive control [PC; commercially relevant ME and balanced amino acids (AA)]; negative control (NC; with reduction of 6% dig. Lys and proportional reductions for adjacent AA compared to the PC), and NC supplemented with sfericase protease [30,000 New Feed Protease units (NFP)/kg]. On day 35, ileal digesta was collected to determine apparent ileal digestibility of dry matter and nitrogen (N). In Exp. 2, 1620 one-day-old male chicks (Cobb 500) were allocated in 54 floor pens having three treatments and 18 replicates of 30 birds each in a completely randomized design from day 1-35. Broilers were fed a control basal diet (Control); Control supplemented with sfericase at 30,000 NFP/kg and at 60,000 NFP/kg. In Exp. 1, from day 1-35, body weight gain (BW gain) and feed conversion ratio (FCR) of broilers improved 3.4 and 2.5% when diets were supplemented with sfericase, respectively, whereas the digestibility of N increased by 2.7% compared to the NC. In Exp. 2, diets with usual protein and AA levels and supplemented with 30,000 NFP/kg had 2.3 and 1.75% improved BW gain and FCR from day 1-35, respectively. When diets were supplemented with 60,000 NFP/kg, BW gain and FCR were enhanced by 3.9 and 3.2%, respectively compared to the Control. In conclusion, these results demonstrate that the novel sfericase protease could be successfully used in corn-soy diets with protein and AA reductions or in feed formulations with usual digestible AA levels to enhance growth performance of broilers.

An impact of N-glycosylation on biochemical properties of a recombinant α-amylase from Bacillus licheniformis.

Amylases are enzymes that are known to hydrolyze starch. High efficiency of amylolytic enzymes allows them to compete in the industry with the technology of chemical hydrolysis of starch. A Bacillus licheniformis strain with high amylolytic activity was isolated from soil and designated as T5. The gene encoding α-amylase from B. licheniformis T5 was successfully expressed in both Escherichia coli (rAmyT5-E) and Pichia pastoris (as rAmyT5-P). According to the study, the recombinant α-amylases rAmyT5-E and rAmyT5-P exhibited the highest activity at pH 6.0 and temperatures of 70 and 80 °C, respectively. Over 80% of the rAmyT5-E enzyme activity was preserved following incubation within the pH range of 5-9; the same was true for rAmyT5-P after incubation at pH 6-9. N-glycosylation reduced the thermal and pH stability of the enzyme. The specific activity and catalytic efficiency of the recombinant AmyT5 α-amylase were also diminished by N-glycosylation.

Improved production of RNA-inhibiting antimicrobial peptide by Bacillus licheniformis MCC 2514 facilitated by a genetic algorithm optimized medium.

One of the significant challenges during the purification and characterization of antimicrobial peptides (AMPs) from Bacillus sp. is the interference of unutilized peptides from complex medium components during analytical procedures. In this study, a semi-synthetic medium was devised to overcome this challenge. Using a genetic algorithm, the production medium of AMP is optimized. The parent organism, Bacillus licheniformis MCC2514, produces AMP in very small quantities. This AMP is known to inhibit RNA biosynthesis. The findings revealed that lactose, NH4Cl and NaNO3 were crucial medium constituents for enhanced AMP synthesis. The potency of the AMP produced was studied using bacterium, Kocuria rhizophila ATCC 9341. The AMP produced from the optimized medium was eightfold higher than that produced from the unoptimized medium. Furthermore, activity was increased by 1.5-fold when cultivation conditions were standardized using the optimized medium. Later, AMP was produced in a 5 L bioreactor under controlled conditions, which led to similar results as those of shake-flask production. The mode of action of optimally produced AMP was confirmed to be inhibition of RNA biosynthesis. Here, we demonstrate that improved production of AMP is possible with the developed semi-synthetic medium recipe and could help further AMP production in an industrial setup.

Modeling and optimization of sporulation by Bacillus licheniformis BF-002 based on dynamics and recurrent neural networks.

Bacillus licheniformis is widely utilized in disease prevention and environmental remediation. Spore quantity is a critical factor in determining the quality of microbiological agents containing vegetative cells. To improve the understanding of Bacillus licheniformis BF-002 strain culture, a hybrid model integrating traditional dynamic modeling and recurrent neural network was developed. This model enabled the optimization of carbon/nitrogen source feeding rates, pH, temperature and agitation speed using genetic algorithms. Carbon and nitrogen source consumption in the optimal duplicate batches showed no significant difference compared to the control batch. However, the spore quantity in the broth increased by 16.2% and 35.2% in the respective duplicate batches. Overall, the hybrid model outperformed the traditional dynamic model in accurately tracking the cultivation dynamics of Bacillus licheniformis, leading to increased spore production when used for optimizing cultivation conditions.

Draft genome sequences of Bacillus licheniformis strains MEZBL63 and MEZBL64 harboring the lichenysin toxin operon isolated from livestock in South Africa.

Here, we report the draft genome sequences of two Bacillus licheniformis strains harboring the lichenysin operon that were isolated from healthy goat and horse in South Africa. The genomes were sequenced using Illumina MiSeq and had a length of 4,152,826 and 4,110,075 bp, respectively, with a G + C content of 46%.

Enhanced sporulation of B. licheniformis BF-002 through automatic co-feeding of carbon and nitrogen sources.

Bacillus licheniformis formulations are effective for environmental remediation, gut microbiota modulation, and soil improvement. An adequate spore quantity is crucial for the activity of B. licheniformis formulations. This study investigated the synergistic effects of carbon/nitrogen source consumption and concentration on B. licheniformis BF-002 cultivation, with the aim of developing an automatic co-feeding strategy to enhance spore production. Initial glucose (10 g/L) and amino nitrogen (1.5 g/L) concentrations promote cell growth, followed by reduced glucose (2.0 g/L) and amino nitrogen (0.5 g/L) concentrations for sustained spore generation. The spore quantity reached 2.59 × 1010 CFU/mL. An automatic co-feeding strategy was developed and implemented in 5 and 50 L cultivations, resulting in spore quantities of 2.35 × 1010 and 2.86 × 1010 CFU/mL, respectively, improving by 6.81% and 30.00% compared to that with a fixed glucose concentration (10.0 g/L). The culture broth obtained at both the 5 and 50 L scales was spray-dried, resulting in bacterial powder with cell viability rates of 85.94% and 82.68%, respectively. Even after exposure to harsh conditions involving high temperature and humidity, cell viability remained at 72.80% and 69.89%, respectively. Employing the automatic co-feeding strategy increased the transcription levels of the spore formation-related genes spo0A, spoIIGA, bofA, and spoIV by 7.42%, 8.46%, 8.87%, and 9.79%, respectively. The proposed strategy effectively promoted Bacillus growth and spore formation, thereby enhancing the quality of B. licheniformis formulations.

Bacillus licheniformis ameliorates Aflatoxin B1-induced testicular damage by improving the gut-metabolism-testis axis.

Global aflatoxin B1 (AFB1) contamination is inevitable, and it can significantly damage testicular development. However, the current mechanism is confusing. Here, by integrating the transcriptome, microbiome, and serum metabolome, we comprehensively explain the impact of AFB1 on testis from the gut-metabolism-testis axis. Transcriptome analysis suggested that AFB1 exposure directly causes abnormalities in testicular inflammation-related signalling, such as tumor necrosis factor (TNF) pathway, and proliferation-related signalling pathways, such as phosphatidylinositide 3-kinases-protein kinase B (PI3K-AKT) pathway, which was verified by immunofluorescence. On the other hand, we found that upregulated inflammatory factors in the intestine after AFB1 exposure were associated with intestinal microbial dysbiosis, especially the enrichment of Bacilli, and enrichment analysis showed that this may be related to NLR family pyrin domain containing 3 (NLRP3)-mediated NOD-like receptor signalling. Also, AFB1 exposure caused blood metabolic disturbances, manifested as decreased hormone levels and increased oxidative stress. Significantly, B. licheniformis has remarkable AFB1 degradation efficiency (> 90%). B. licheniformis treatment is effective in attenuating gut-testis axis damage caused by AFB1 exposure through the above-mentioned signalling pathways. In conclusion, our findings indicate that AFB1 exposure disrupts testicular development through the gut-metabolism-testis axis, and B. licheniformis can effectively degrade AFB1.

Effects of Feather Hydrolysates Generated by Probiotic Bacillus licheniformis WHU on Gut Microbiota of Broiler and Common carp.

Due to the ever-increasing demand for meat, it has become necessary to identify cheap and sustainable sources of protein for animal feed. Feathers are the major byproduct of poultry industry, which are rich in hard-to-degrade keratin protein. Previously we found that intact feathers can be digested into free amino acids, short peptides, and nano-/micro-keratin particles by the strain Bacillus licheniformis WHU in water, and the resulting feather hydrolysates exhibit prebiotic effects on mice. To explore the potential utilization of feather hydrolysate in the feed industry, we investigated its effects on the gut microbiota of broilers and fish. Our results suggest that feather hydrolysates significantly decrease and increase the diversity of gut microbial communities in broilers and fish, respectively. The composition of the gut microbiota was markedly altered in both of the animals. The abundance of bacteria with potentially pathogenic phenotypes in the gut microbial community of the fish significantly decreased. Staphylococcus spp., Pseudomonas spp., Neisseria spp., Achromobacter spp. were significantly inhibited by the feather hydrolysates. In addition, feather hydrolysates significantly improved proteolytic activity in the guts of broilers and fish. In fish, the expression levels of ZO-1 and TGF-α significantly improved after administration of feather hydrolysates. The results presented here suggest that feather hydrolysates generated by B. licheniformis WHU could be an alternative protein source in aquaculture and could exert beneficial effects on fish.

Effects of bacterial direct-fed microbial combinations on beef cattle growth performance, feeding behavior, nutrient digestibility, ruminal morphology, and carcass characteristics.

The effects of the dietary inclusion of a mixture of bacterial direct-fed microbial (DFM) on feedlot beef cattle growth performance, carcass characteristics, nutrient digestibility, feeding behavior, and ruminal papillae morphology were evaluated. Crossbred-Angus steers (n = 192; initial body weight (BW) = 409 kg ±â€…8 kg) were blocked by BW and randomly assigned into 48 pens (4 steers/pen and 16 pens/treatment) following a randomized complete block design. A steam-flaked corn-based fishing diet was offered to ad libitum intake once daily for 153 d containing the following treatments: (1) Control (no DFM, lactose carrier only); (2) treat-A (Lactobacillus animalis, Propionibacterium freudenreichii, Bacillus subtilis, and Bacillus licheniformis), at 1:1:1:3 ratio, respectively; totaling 6 × 109 CFU (50 mg)/animal-daily minimum; and (3) treat-B, the same DFM combination, but with doses at 1:1:3:1 ratio. Bacterial counts were ~30% greater than the minimum expected. Data were analyzed using the GLIMMIX procedure of SAS, with pen as the experimental unit, the fixed effect of treatment, and the random effect of BW-block, while preplanned contrasts comparing Control × treat-A or treat-B were used. Steers offered treat-A had increased carcass-adjusted average daily gain (P = 0.03) by 6.7%, gain efficiency (P < 0.01) by 6%, tended (P = 0.07) to have increased carcass-adjusted final BW by 15 kg, and hot carcass weight (P = 0.07) by 10 kg, while treat-B did not differ (P ≥ 0.17) from control. Overall dry matter (DM) intake (P = 0.36) and other carcass traits (P ≥ 0.13) were not affected by treatments. Steers offered treat-A tended to have increased digestibility of DM (P = 0.07) by 3%, neutral detergent fiber (P = 0.10), and hemicellulose (P = 0.08) by 9% compared with control, while treat-B did not differ (P ≥ 0.10) from control. No treatment × period interactions (P ≥ 0.21) or main effects of treatment (P ≥ 0.12) were observed during 24-h feeding behavior. Steers ruminated, ate, chewed, and were more active (P ≤ 0.01) during the second behavioral assessment (day 113), while drinking behavior was not affected (P ≥ 0.88). Ruminal papillae morphology and ruminal ammonia concentration (ruminal fluid collected at slaughter facility) were not affected by treatment (P ≥ 0.39). Steers offered the DFM treat-A had improved growth performance and it positively affected carcass weight and nutrient digestion. The DFM combinations did not seem to affect feedlot cattle feeding behavior or ruminal papillae morphology.

Direct-fed microbials (DFM) are naturally occurring microorganisms that alter cattle ruminal fermentation and intestinal function and have been shown to improve growth performance and nutrient digestibility of cattle. The use of DFM in animal feed has continuously increased in feedlots as an alternative to traditional antibiotic additives, which have gained negative public perception and additional regulatory scrutiny. High-energy diets can induce physiological challenges to cattle, especially when based on high starch availability ingredients, which may negatively affect animal growth performance. Such physiological digestive challenges may be overcome by a target combination of DFM bacterial strains (Lactobacillus animalis, Propionibacterium freudenreichii, Bacillus subtilis, and Bacillus licheniformis). These microorganisms individually have shown to have positive effects on finishing cattle offered high-energy diets, which highlights the need for research to optimize DFM types and doses to enhance the use of bacterial strains that can positively affect cattle growth performance, carcass traits, nutrient digestibility, and other variables relevant to the physiology of digestion. In the current experiment, feedlot steers offered a specific bacterial DFM combination/dose had improved average daily gain and feed efficiency, which were reflected as a positive influence on hot carcass weight and digestibility of nutrients, while not effectcting feeding behavior and ruminal morphology.

Secretory expression of amylosucrase in Bacillus licheniformis through twin-arginine translocation pathway.

Amylosucrase (EC 2.4.1.4) is a versatile enzyme with significant potential in biotechnology and food production. To facilitate its efficient preparation, a novel expression strategy was implemented in Bacillus licheniformis for the secretory expression of Neisseria polysaccharea amylosucrase (NpAS). The host strain B. licheniformis CBBD302 underwent genetic modification through the deletion of sacB, a gene responsible for encoding levansucrase that synthesizes extracellular levan from sucrose, resulting in a levan-deficient strain, B. licheniformis CBBD302B. Neisseria polysaccharea amylosucrase was successfully expressed in B. licheniformis CBBD302B using the highly efficient Sec-type signal peptide SamyL, but its extracellular translocation was unsuccessful. Consequently, the expression of NpAS via the twin-arginine translocation (TAT) pathway was investigated using the signal peptide SglmU. The study revealed that NpAS could be effectively translocated extracellularly through the TAT pathway, with the signal peptide SglmU facilitating the process. Remarkably, 62.81% of the total expressed activity was detected in the medium. This study marks the first successful secretory expression of NpAS in Bacillus species host cells, establishing a foundation for its future efficient production. ONE-SENTENCE SUMMARY: Amylosucrase was secreted in Bacillus licheniformis via the twin-arginine translocation pathway.

A new ROS response factor YvmB protects Bacillus licheniformis against oxidative stress under adverse environment.

Bacillus spp., a class of aerobic bacteria, is widely used as a biocontrol microbe in the world. However, the reactive oxygen species (ROS) will accumulate once the aerobic bacteria are exposed to environmental stresses, which can decrease cell activity or lead to cell death. Hydroxyl radical (·OH), the strongest oxide in the ROS, can damage DNA directly, which is generated through Fenton Reaction by H2O2 and free iron. Here, we proved that the synthesis of pulcherriminic acid (PA), an iron chelator produced by Bacillus spp., could reduce DNA damage to protect cells from oxidative stress by sequestrating excess free iron, which enhanced the cell survival rates in stressful conditions (salt, antibiotic, and high temperature). It was worth noting that the synthesis of PA was found to be increased under oxidative stress. Thus, we demonstrated that the YvmB, a direct negative regulator of PA synthesis cluster yvmC-cypX, could be oxidized at cysteine residue (C57) to form a dimer losing the DNA-binding activity, which led to an improvement in PA production. Collectively, our findings highlight that YvmB senses ROS to regulate PA synthesis is one of the evolved proactive defense systems in bacteria against adverse environments.IMPORTANCEUnder environment stress, the electron transfer chain will be perturbed resulting in the accumulation of H2O2 and rapidly transform to ·OH through Fenton Reaction. How do bacteria deal with oxidative stress? At present, several iron chelators have been reported to decrease the ·OH generation by sequestrating iron, while how bacteria control the synthesis of iron chelators to resist oxidative stress is still unclear. Our study found that the synthesis of iron chelator PA is induced by reactive oxygen species (ROS), which means that the synthesis of iron chelator is a proactive defense mechanism against environment stress. Importantly, YvmB is the first response factor found to protect cells by reducing the ROS generation, which present a new perspective in antioxidation studies.

Molecular mechanism of cellulose depolymerization by the two-domain BlCel9A enzyme from the glycoside hydrolase family 9.

Carbohydrate-active enzymes from the glycoside hydrolase family 9 (GH9) play a key role in processing lignocellulosic biomass. Although the structural features of some GH9 enzymes are known, the molecular mechanisms that drive their interactions with cellulosic substrates remain unclear. To investigate the molecular mechanisms that the two-domain Bacillus licheniformis BlCel9A enzyme utilizes to depolymerize cellulosic substrates, we used a combination of biochemical assays, X-ray crystallography, small-angle X-ray scattering, and molecular dynamics simulations. The results reveal that BlCel9A breaks down cellulosic substrates, releasing cellobiose and glucose as the major products, but is highly inefficient in cleaving oligosaccharides shorter than cellotetraose. In addition, fungal lytic polysaccharide oxygenase (LPMO) TtLPMO9H enhances depolymerization of crystalline cellulose by BlCel9A, while exhibiting minimal impact on amorphous cellulose. The crystal structures of BlCel9A in both apo form and bound to cellotriose and cellohexaose were elucidated, unveiling the interactions of BlCel9A with the ligands and their contribution to substrate binding and products release. MD simulation analysis reveals that BlCel9A exhibits higher interdomain flexibility under acidic conditions, and SAXS experiments indicate that the enzyme flexibility is induced by pH and/or temperature. Our findings provide new insights into BlCel9A substrate specificity and binding, and synergy with the LPMOs.

Probiotic Bacillus licheniformis ZW3 Alleviates DSS-Induced Colitis and Enhances Gut Homeostasis.

Despite Bacillus species having been extensively utilized in the food industry and biocontrol as part of probiotic preparations, limited knowledge exists regarding their impact on intestinal disorders. In this study, we investigated the effect of Bacillus licheniformis ZW3 (ZW3), a potential probiotic isolated from camel feces, on dextran sulfate sodium (DSS)-induced colitis. The results showed ZW3 partially mitigated body weight loss, disease activity index (DAI), colon shortening, and suppressed immune response in colitis mice, as evidenced by the reduction in the levels of the inflammatory markers IL-1ß, TNF-α, and IL-6 (p < 0.05). ZW3 was found to ameliorate DSS-induced dysfunction of the colonic barrier by enhancing mucin 2 (MUC2), zonula occluden-1 (ZO-1), and occludin. Furthermore, enriched beneficial bacteria Lachnospiraceae_NK4A136_group and decreased harmful bacteria Escherichia-Shigella revealed that ZW3 improved the imbalanced gut microbiota. Abnormally elevated uric acid levels in colitis were further normalized upon ZW3 supplementation. Overall, this study emphasized the protective effects of ZW3 in colitis mice as well as some potential applications in the management of inflammation-related diseases.